1. Welcome to 4Runners.com!

    You are currently viewing as a guest! To get full-access, you need to register for a FREE account.

    As a registered member, you’ll be able to:
    • Participate in all 4Runner discussion topics
    • Transfer over your build thread from a different forum to this one
    • Communicate privately with other 4Runner owners from around the world
    • Post your own photos in our Members Gallery
    • Access all special features of the site

Tire Chalk Test - How to guide

Discussion in 'Wheels & Tires' started by csuviper, Jan 5, 2016.

  1. Jan 5, 2016 at 8:43 PM
    #1
    csuviper

    csuviper [OP] Moderator Staff Member

    Joined:
    Oct 31, 2015
    Member:
    #1119
    Messages:
    122
    Gender:
    Male
    Vehicle:
    Tundra RW 4x4 5.7L
    This method of checking tire pressure, called the chalk test, demonstrates if your tire is bulging from too much pressure or if it is slightly concave from a lack of pressure

    IMG_5749_64d60939fe356c5de9edbc49e4c28c67fe272841.jpg

    Instructions

    1. Fill the tires to a good starting pressure. If you are unsure what pressure to start with then subtract 10 percent from the manufacturer's maximum inflation pressure on the side of the tire. If, for example, the maximum is 40 psi, then 10 percent of 40 is 4. Subtract the 10 percent value from the maximum psi value. So, 40 - 4 = 36. Use 36 psi in your tires. You could also use the following calculation for the starting pressure.
      • Weight of vehicle / (Manufacturers weight rating x 4)) x Manufacturers inflation pressure at weight rating
    2. Drive to a flat area. This can be your driveway or the street in front of your house. Just make sure there aren't a lot of cracks, bumps or pot holes in the ground.
    3. Using chalk, draw a thick, straight line across the width of the tire.
    4. Use Test Variance 1 or Test Variance 2 for the completion of the instructions.

    Test Variance 1

    1. Drive the truck forward at least one-full truck length.
    2. Inspect the chalk on the ground. A tire with the proper air pressure should press the chalk line evenly across the ground. This means you'll see the entire chalk line imprinted on the ground. If your tire is over-inflated, you'll only see a small portion of line in the center. If you're tire is underinflated, you'll see only the sides of the lines since the middle of the tire is not making contact with the ground.
    3. Adjust your tire's air pressure according to the chalk test results and try again until you get the chalk line to press evenly across the ground.

    Test Variance 2

    1. Drive the truck to the end of the street and back or around the block.
    2. Inspect the chalk on the tire. A tire with the proper air pressure will show the chalk evenly worn across the tire. If your tire is over-inflated, the center of the line will be worn more than the edges. If you're tire is underinflated, the outer edges of the line will be worn more than the center.
    3. Adjust your tire's air pressure according to the chalk test results and try again until you get the chalk line to evenly wear across the tire.




    Over-Inflated = More wear on the center of the tire = center of chalk line visible on ground = chalk line worn more in center

    Under-Inflated = More wear on the outer edges of the tire = outer edges of chalk line visible on ground = chalk line worn more on outer edges
     
    Bob and ajohnson like this.
  2. Jan 7, 2016 at 8:15 PM
    #2
    ramonortiz55

    ramonortiz55 New Member

    Joined:
    May 3, 2015
    Member:
    #590
    Messages:
    1,489
    Gender:
    Male
    First Name:
    Ramon
    Vehicle:
    2001 4runner limited silver millenium
    Thank you viper.
     
  3. Jan 7, 2016 at 8:15 PM
    #3
    ramonortiz55

    ramonortiz55 New Member

    Joined:
    May 3, 2015
    Member:
    #590
    Messages:
    1,489
    Gender:
    Male
    First Name:
    Ramon
    Vehicle:
    2001 4runner limited silver millenium
    where is the thumbs up emoticon?
     
  4. Jan 7, 2016 at 8:35 PM
    #4
    csuviper

    csuviper [OP] Moderator Staff Member

    Joined:
    Oct 31, 2015
    Member:
    #1119
    Messages:
    122
    Gender:
    Male
    Vehicle:
    Tundra RW 4x4 5.7L
  5. Jan 8, 2016 at 12:29 PM
    #5
    ramonortiz55

    ramonortiz55 New Member

    Joined:
    May 3, 2015
    Member:
    #590
    Messages:
    1,489
    Gender:
    Male
    First Name:
    Ramon
    Vehicle:
    2001 4runner limited silver millenium
    hmm
     
  6. Jan 8, 2016 at 12:30 PM
    #6
    ramonortiz55

    ramonortiz55 New Member

    Joined:
    May 3, 2015
    Member:
    #590
    Messages:
    1,489
    Gender:
    Male
    First Name:
    Ramon
    Vehicle:
    2001 4runner limited silver millenium
  7. Jan 8, 2016 at 12:30 PM
    #7
    ramonortiz55

    ramonortiz55 New Member

    Joined:
    May 3, 2015
    Member:
    #590
    Messages:
    1,489
    Gender:
    Male
    First Name:
    Ramon
    Vehicle:
    2001 4runner limited silver millenium
    They're not in the same order as on TW :facepalm:
     
    ThatFenwickGuyFromTW likes this.
  8. Jan 11, 2016 at 4:44 PM
    #8
    ThatFenwickGuyFromTW

    ThatFenwickGuyFromTW Hillbilly

    Joined:
    Nov 26, 2015
    Member:
    #1227
    Messages:
    148
    Gender:
    Male
    First Name:
    Fenwick
    Chesapeake, VA
    Vehicle:
    2 2nd Gen T4R's, 96 Tacoma 5 Lug
    Work in progress!
    Gets me, too!
     
To Top